1. PRODUCT INDENTIFICATION /GENERAL INFORMATION
Chemical Descrption: Water-Gel Emulsion
Formula: Proprietary
Product Name: Gel Cable Lubricant 0.33qt and 1qt
Product Type: Cable Lubricant
2. COMPOSITION/INFORMATION ON INGREDIENTS
This product contains no reportable hazardous components under 29 CFR1910.1200. There are no OSHA or ACGIH threshold limit values for the product or any of its ingredients.
3. HAZARDS INDENTIFICATION
Estimated NFPA Rating: Health 1, Flammability 0, Reactivity 0
Estimated HMIS Classification: Health 0, Flammability 0, Physical Hazard 0
Key: 0-minimal 1-slight 2-moderate 3- serious 4- severe
NFPA is a registered trademark of the National Fire Protection Association.
HMIS Is a registered trademark of the National Paint and Coatings Association.
4. FIRST AID
Eye Contact: Flush eyes with a large quantity of water for 15 minutes.
If irrtation continues, seek medical attention.
Skin Contact: If skin becomes irritated, wash area thoroughly with soap and water.
If irritation continues, seek medical attention.
Inhalation (Breathing) : No first aid expected to be required. Not an inhalation hazard.
Ingestion (Swallowing): No first aid expected to be required. If difficulties arise, contact a physician.
5. FIRE AND EXPLOSION HAZARD
Flash Point: No flash via COC method.
Flammable Limits: Product is not flammable.
Extinguishing Media: Does not apply.
Special Procedures: Does not apply.
Unusual Hazards: Sealed container can build up pressure when exposed to high heat.
Cool contaners with water.
Hazardous Decomposition Products:
High temperature steam, potentially carbon monoxide and carbon dioxide.
6. ACCIDENTAL RELEASE MEASURES
FCC Gel cable lubricant is extremely slippery. It should be washed, swept, or squeegeed from floor using wet mops. Oxidizing agents, such as household bleach, can be used to eliminate the slippery character. Outside, spills should be covered with sand, dirt, gravel or calcium chloride.
7. HANDLING AND STORAGE
Handing: Avoid spills and clean them up immediately when they occur. Product is very slippery.
Storage: Keep product containers closed when not in use. Store at temperatures between 40-180F. Avoid freezing.
Other Precautions: Keep away from children, Infants and pets.
8. EXPOSURE CONTROL / PERSONAL PROTECTION
Respiratory Protection: Normal ventilation adequate.
Ventilation : General ventilation is usually adequate.
Eye Protection: Safety glasses(recommended) or splash goggles.
Protective Gloves: For repeated or prolonged skin contact, the use of impermeable gloves
is recommended to prevent drying and possible irritation.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: light yellow gel
Odor: odorless
Boiling Point: 212°F (~100℃)
pH: 6.5 to 7.5 (neutral)
Ignition Temperature: None
Specific Gravity (H2O=1): 0.95±0.02
Percent Volatiles (Weight%): ＜90
Solubility in Water: moderate
10. STABILITY AND REACTIVITY
Stability: Stable at normal condition
Hazardous Polymerization: Will not occur
Incompatibility: Avoid materials that react with water.
Hazardous Products Formed by Fire or Thermal Decomposition: None
11. HEALTH HAZARD/TOXICOLOGICAL INFORMATION
Primary Routes of Entry: Inhalation and Skin Contact, Eye, Ingestion.
Eye Contact: Direct eye contact may cause eye irritation.
Skin Contact: This product has low skin irritation potential. There is no dermal toxicity hazard.
Inhalation (Breathing): No inhalation hazard expected with water vapor.
Ingestion (Swallowing): Based on ingredients, LD50 (rat) is estimated to be well over 50g/kg.
Carcinogenic Status: This substance has not been identified as a carcinogen or probable carcinogen by NTP,IARC or OSHA, nor have any of its components.
12. ECOLOGICAL INFORMATION
See Section 11
13. DISPOSAL CONSIDERATIONS
Waste Disposal Methods: Comply with federal,state, and local regulations for solid landfill. FCC gel cable lubricant is not considered hazardous under RCRA.
14. TRANSPORTATION INFORMATION
DOT(Department of Transportation)
Domestic Ground Transport
DOT Shipping Name: Unrestricted
Hazard Class: None
UN/ID Number: None
Marine Pollutant: None
Product Name: FCC Gel Cable Lubricant .33qt and 1qt.
15. REGULATORY INFORMATION
All components for this product are listed on the TSCA inventory. See Section 2
16. OTHER INFORMATION
Approved by: Chen Jin, Health and Safety Manager Revision Date: 04/12/2006
Prepared by: Yang MengQing Revision Summary: New MSDS
NA: Not Applicable NDA: No data available <: Less than >: more than
We believe the statements, technical information and recommendations contained herein are reliable. However, the data is provided without warranty, expressed or implied. It is the user’s responsibility both to determine safe conditions for use of this product and assume loss, damage or expense, direct or consequential, arising from its use. Before using product, read lable.
Note:
** None of the chemical raw materials contained in this formulation are considered hazardous under the Federal Hazards Communication Standard 29 C. F. R 1910.1200
*** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] ARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only
